Chevrolet Volt Forums: Chevy Volt Forum - Reply to Topic
Thread: GM road-tests batteries for Volt electric car Reply to Thread
Send Trackbacks to (Separate multiple URLs with spaces) :
Post Icons
You may choose an icon for your message from the following list:

Register Now

In order to be able to post messages on the Chevrolet Volt Forums: Chevy Volt Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Please enter a password for your user account. Note that passwords are case-sensitive.


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:


Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.

  Additional Options
Miscellaneous Options

  Topic Review (Newest First)
08-18-2008 09:56 AM
aliac no bad .
thanks .
04-26-2008 02:32 PM
JBsC6 the Volt showcar looks great. Hope the final product comes close.

I am sure the performance will be more than enough for the average consumer looking for economy.

Thanks for the heads up on the testing info
04-03-2008 09:58 PM
GM road-tests batteries for Volt electric car

WARREN, Michigan (AP) -- The lithium-ion batteries to be used in General Motors' Chevrolet Volt electric car will soon be installed and tested in specially-equipped versions of the Chevrolet Malibu, the company said. This will allow the automaker to test the batteries in actual driving situations, the company said during a media event in the Detroit suburb of Warren.

According to GM's plans, the Volt will be produced as a mainstream electric vehicle that can be recharged by being plugged into a household outlet. It will have a small gasoline engine that will be used only to recharge the vehicle's batteries if they run down while driving. Because of the extreme power demands involved in driving a car in the real world, the vehicle would be powered by lithium-ion batteries. Lithium-ion batteries are lighter and can store and release more power than the nickel-metal hydride batteries used in today's hybrid cars. Fully charged, the Volt should drive about 40 miles without using any gasoline, according to GM (GM, Fortune 500). The small conventional engine would extend that range allowing the car to get as much 150 miles per gallon, depending on the distance driven.

The Volt will be a four-seat car. Not having a center seating position in the back will allow room for the car's battery to run longitudinally down the center of the car while keeping the roof low for better aerodynamics, according to a GM press release. The T-shaped battery will also extend out under the back seats.

"After extensive aerodynamic testing of the Volt, the vehicle now has a coefficient of drag that is 30% lower than the original concept," said Ed Welburn, GM vice president, Global Design. "It's not easy, but it is a necessity."

GM also announced a new computer algorithm to speed laboratory-based durability testing of the batteries. "Production timing of the Volt is directly related to our ability to predict how this battery will perform over the life of the vehicle. The challenge is predicting 10 years of battery life with just over two years of testing time," said Frank Weber, global vehicle chief engineer for the Volt.

GM recently announced that it will begin using lithium-ion batteries in mild-hybrid vehicles such as the Chevrolet Malibu Hybrid and Saturn Vue Hybrid. While those vehicles will still run under gasoline power, with just an assist from electric motors, using lithium-ion batteries will greatly boost fuel economy.

The company also expects to release a plug-in hybrid version of its Saturn Vue Green Line in 2009. Unlike the Volt, the Saturn Vue plug-in will operate like a typical hybrid car, with a gasoline engine and electric motor working together to power the vehicle.


Posting Rules  
You may not post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

For the best viewing experience please update your browser to Google Chrome